Zanussi ZHC62653XA Cooker Hood User Manual

User Manual
GETTING STARTED?
EASY.

ZHC62352X/ ZHC62653XA/ ZHC92352X
ZHC92653XA/ ZFLX16A/ ZFLX19A
ZFLX26A/ ZFLX29A 
EN User Manual
Cooker Hood

VISIT OUR WEBSITE TO:

Get usage advice, brochures, troubleshooter, service, and repair information: www.zanussi.com/support

SAFETY INFORMATION

Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible for any injuries or damage that are the result of incorrect installation or usage. Always keep the instructions in a safe and accessible location for future reference.

CHILDREN AND VULNERABLE PEOPLE SAFETY

  • This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved. Children of less than 8 years of age and persons with very extensive and complex disabilities shall be kept away from the appliance unless continuously supervised.
  • Children should be supervised to ensure that they do not play with the appliance.
  • Keep all packaging away from children and dispose of it appropriately.
  • Keep children and pets away from the appliance when it operates.
  • Children shall not carry out cleaning and user maintenance of the appliance without supervision.
    GENERAL SAFETY
  • This appliance is intended for domestic use above hobs, cookers, and similar cooking devices.
  • Before carrying out any maintenance, disconnect the appliance from the power supply.
  • CAUTION: Accessible parts may become hot during use with cooking appliances.
  • Use only the fixing screws supplied with the appliance if not supplied, use the screws recommended in the installation instructions. Install the appliance in a safe and suitable place that meets installation requirements.
  • WARNING: Failure to install the screws or fixing the device in accordance with these instructions may result in electrical hazards.
  • Do not use adhesives to fix the appliance.
  • The minimum distance between the hob surface on which the pans stand and the lower part of the appliance shall be at least 65 cm unless otherwise specified in the installation instructions for the appliance or hob.
  • The discharge of air must comply with local authorities’ regulations.
  • Ensure good air ventilation in the room where the appliance is installed to avoid the backflow of gases into the room from appliances burning gas or other fuels, including open fires.
  • Make sure that the ventilation openings are not blocked and the air collected by the appliance is not conveyed into a duct used to exhaust smoke and steam from other appliances (central heating systems, thermosiphons, water-heaters, etc.).
  • When the appliance operates with other appliances the maximum vacuum generated in the room should not exceed 0.04 bar.
  • Make sure not to cause damage to the main cable. Contact our Authorised Service Centre or an electrician to change a damaged mains cable.
  • If the appliance is connected directly to the power supply, the electrical installation must be equipped with an isolating device that allows disconnecting the appliance from the mains at all poles. Complete disconnection must comply with conditions specified in the overvoltage category III. The means for disconnection must be incorporated in the fixed wiring in accordance with the wiring rules.
  • Do not flambé under the appliance.
  • Do not use to exhaust hazardous or explosive materials and vapors.
  • Clean the appliance regularly with a soft cloth to prevent the deterioration of the surface material.
  • Do not use a steam cleaner, water spray, harsh abrasive cleaners or sharp metal scrapers to clean the surface of the appliance. Use only neutral detergents.
  • Clean grease filters regularly (at least every 2 months) and remove grease deposits from the appliance to prevent the risk of fire.
  • Use a cloth to clean the interior of the appliance.

SAFETY INFORMATION

Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible for any injuries or damage that are the result of incorrect installation or usage. Always keep the instructions in a safe and accessible location for future reference.

SAFETY WARNINGS

This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved. Children of less than 8 years of age and persons with very extensive and complex disabilities shall be kept away from the appliance unless continuously supervised. Children must not play with the appliance. Keep all packaging away from children and dispose of it appropriately. Children shall not carry out cleaning and user maintenance of the appliance without supervision. If the appliance has a child safety device, it should be activated.
WARNING: The appliance and its accessible parts become hot during use. Care should be taken to avoid touching heating elements.
WARNING: Ensure that the appliance is switched off before replacing the lamp to avoid the possibility of electric shock.
If the supply cord is damaged, it must be replaced with an identical one by the manufacturer, its service agent or similarly qualified persons in order to avoid a hazard – risk of electrical shock.
This appliance is for household use only. Do not change the specification of this appliance.
Always cook with the oven door closed. Use oven gloves to remove pans and accessories.
Do not use a steam cleaner to clean the appliance. Do not use harsh abrasive cleaners or sharp metal scrapers to clean the glass door since they can scratch the surface, which may result in shattering of the glass. The means for disconnection must be incorporated in the fixed wiring in accordance with the wiring rules.

INSTALLATION

WARNING!
Risk of injury, electric shock, fire, burns or damage to the appliance.

  • Only a qualified person must install this appliance.
  • Do not install or use a damaged appliance.
  • Follow the installation instructions supplied with the appliance.
  • Always take care when moving the appliance as it is heavy. Always use safety gloves and enclosed footwear.
  • Before installing the appliance remove all the packaging, the labeling, and the protective film.
  • Do not install the exhaust air into a wall cavity, unless the cavity is designed for that purpose.

ELECTRICAL CONNECTION

WARNING!
Risk of fire and electric shock.

  • All electrical connections should be made by a qualified electrician.
  • Make sure that the parameters on the rating plate are compatible with the electrical ratings of the main power supply.
  • If the symbol ( ) is not printed on the rating plate, the appliance must be earthed.
  • Always use a correctly installed shockproof socket.
  • Do not let the electricity mains cable tangle.
  • Do not use multi-plug adapters and extension cables.
  • If the main socket is loose, do not connect the main plug.
  • Do not pull the main cable to disconnect the appliance. Always pull the mains plug.
  • The shock protection of live and insulated parts must be fastened in such a way that it cannot be removed without tools.
  • Make sure the appliance is installed correctly. Loose and incorrect electricity mains cable can make the terminal become too hot.
  • Connect the appliance at the end of the installation. Make sure that there is access to the mains after the installation.

USE

WARNING!
Risk of injury, burns, and electric shock.

  • This appliance is for cooking purposes only. Do not use the appliance for another purpose.
  • Do not change the specification of this appliance.
  • Do not operate the appliance with wet hands or when it has contact with water.
  • Use only the accessories supplied with the appliance.
  • Keep flames or heated objects away from fats and oils during cooking and frying.
  • Do not use uncovered electric grills.
  • Do not use the appliance as a storage surface.
  • Do not use magnifying glasses, binoculars, or similar optical devices to look directly at the lighting of the appliance.

SERVICE

  • To repair the appliance contact the Authorised Service Centre. Use original spare parts only.
  • Concerning the lamp(s) inside this product and spare part lamps sold separately: These lamps are intended to withstand extreme physical conditions in household appliances, such as temperature, vibration, humidity, or are intended to signal information about the operational status of the appliance. They are not intended to be used in other applications and are not suitable for household room illumination.

DISPOSAL

WARNING!
Risk of injury or suffocation.

  • Contact your municipal authority for information on how to dispose of the appliance.
  • Disconnect the appliance from the main supply.
  • Cut off the mains electrical cable close to the appliance and dispose of it.

INSTALLATION

WARNING! Refer to Safety chapters.

INSTALLATION INSTRUCTIONS
For complete information about the installation of the appliance refer to a separate installation booklet.

PRODUCT DESCRIPTION

CONTROL PANEL OVERVIEW

1 Function Description
2 Lamp Turns the lights on and off.
3 First speed / Off The motor switches to the first speed level. The second press turns off the appliance.
4 Second speed The motor switches to a second speed level.
5 Third speed The motor switches to the third speed level.

DAILY USE

USING THE HOOD
Check the recommended speed according to the table below.

0-1 While heating up food, cooking with covered pots.
2 While cooking with covered pots on multiple cooking zones or burners, gentle frying.
3 While boiling and frying big quantities of food without a lid, cooking on multiple cooking zones or burners.

It is recommended to leave the hood operating for approximately 15 minutes after cooking.
The hood’s light works independently of other hood functions. To illuminate the cooking surface press the light button To turn off the appliance press the first speed
button0-1 again.
To operate the hood:
1. Press the first speed button0-1 to switch on the appliance.
2. If needed, change the speed by pressing the desired button.

CARE AND CLEANING

NOTES ON CLEANING

Cleaning Agents Do not use abrasive detergents and brushes.
Clean the surface of the appliance with a soft cloth with warm water and a mild detergent.
After cooking some parts of the appliance can get hot. To avoid stains appliance must be cooled down and dried with a clean cloth or paper towels.
Clean stains with a mild detergent.
Keep the hood clean Clean the appliance and grease filters each month. Clean the interior and grease
filters carefully from fat. Fat accumulation or another residue may cause a fire.
Grease filters can be washed in a dishwasher. The dishwasher must be set to a low temperature and a short cycle. The grease filter may discolor, it has no influence on the performance of the appliance.
 Charcoal filter The time of saturation of the charcoal filter varies depending on the type of cooking and the regularity of cleaning the grease filter. The activated charcoal filter is not washable, cannot be regenerated, and must be replaced approximately every 4/6 months of operation, or more frequently for particularly heavy usage.

CLEANING THE GREASE FILTER
Filters are mounted with the use of clips and pins on the opposite side.
To clean the filter:

  1. Press the handle of the mounting clip on the filter panel underneath the hood (1).
  2. Slightly tilt the front of the filter downwards (2), then pull. Repeat the first two steps for all filters.
  3. Clean the filters using a sponge with nonabrasive detergents or in a dishwasher.
    The dishwasher must be set to a low temperature and a short cycle. The grease filter may discolor, it has no influence on the performance of the appliance.
  4. To mount the filters back follow the first two steps in reverse order. Repeat the steps for all filters if applicable.

ENVIRONMENTAL CONCERNS

Recycle materials with the symbol. Put the packaging in relevant containers to recycle it. Help protect the environment and human health by recycling waste of electrical and electronic appliances. Do not dispose of appliances marked

REPLACING THE CHARCOAL FILTER
WARNING! The charcoal filter is nonwashable! To replace the filter:

  1. Remove the grease filters from the appliance. Refer to “Cleaning the grease filter” in this chapter.
  2. Press the front edge in the slot towards the bottom part of the filter. Slightly tilt the front of the filter downwards.
  3. To install a new filter, perform the same steps in reverse order. In any case, it is necessary to replace the filters at least every four months.

REPLACING THE LAMP
This appliance is supplied with a LED lamp and separate control gear (LED driver). These parts can be replaced by a technician only. In case of any malfunction refer to  “Service” in the “Safety Instructions” chapter.
with the household waste. Return the product to your local recycling facility or contact your municipal office. with the symbol