Whirlpool W11510323A Microwave Oven Instructions

Whirlpool W11510323A Microwave Oven

MICROWAVE OVEN SAFETY

Your safety and the safety of others are very important.

We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages.

DANGER
You can be killed or seriously injured if you don’t immediately follow instructions.

WARNING
You can be killed or seriously injured if you don’t follow instructions.

All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can happen if the instructions are not followed.

IMPORTANT SAFETY INSTRUCTIONS

When using electrical appliances basic safety precautions should be followed, including the following:

WARNING: To reduce the risk of burns, electric shock, fire, injury to persons, or exposure to excessive microwave energy:

• Read all instructions before using the microwave oven.
• Read and follow the specific “PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY” found in this section.
• The microwave oven must be grounded. Connect only to properly grounded outlet. See “GROUNDING INSTRUCTIONS” found in the “INSTALLATION INSTRUCTIONS” section.
• Install or locate the microwave oven only in accordance with the provided Installation Instructions.
• Some products such as whole eggs in the shell and sealed containers – for example, closed glass jars – are able to explode and should not be heated in the microwave oven.
• Use the microwave oven only for its intended use as described in the manual. Do not use corrosive chemicals or vapors in the microwave oven. This type of oven is specifically designed to heat, cook, or dry food. It is not designed for industrial or laboratory use.
• As with any appliance, close supervision is necessary when used by children.
• Do not operate the microwave oven if it has a damaged cord or plug, if it is not working properly, or if it has been damaged or dropped.
• The microwave oven should be serviced only by qualified service personnel. Call an authorized service company for examination, repair, or adjustment.
• Do not cover or block any openings on the microwave oven.
• Do not store this microwave oven outdoors. Do not use the microwave oven near water – for example, near a kitchen sink, in a wet basement, near a swimming pool, or similar locations.
• Do not immerse cord or plug in water.
• Keep cord away from heated surfaces.
• Do not let cord hang over edge of table or counter.
• See door surface cleaning instructions in the “Microwave Oven Care” section.
• To reduce the risk of fire in the oven cavity:
  • Do not overcook food. Carefully attend the microwave oven when paper, plastic, or other combustible materials are placed inside the oven to facilitate cooking.
  • Remove wire twist-ties from paper or plastic bags before placing bags in oven.
  • If materials inside the oven ignite, keep oven door closed, turn oven off, and disconnect the power cord, or shut off power at the fuse or circuit breaker panel.
  • Do not use the cavity for storage purposes. Do not leave paper products, cooking utensils, or food in the cavity when not in use.
    SAVE THESE INSTRUCTIONS
• Liquids, such as water, coffee, or tea are able to be overheated beyond the boiling point without appearing to be boiling. Visible bubbling or boiling when the container is removed from the microwave oven is not always present. THIS COULD RESULT IN VERY HOT LIQUIDS SUDDENLY BOILING OVER WHEN THE CONTAINER IS DISTURBED OR A SPOON OR OTHER UTENSIL IS INSERTED INTO THE LIQUID.
• To reduce the risk of injury to persons:
  • Do not overheat the liquid.
  • Stir the liquid both before and halfway through heating it.
  • Do not use straight-sided containers with narrow necks.
  • After heating, allow the container to stand in the microwave oven for a short time before removing the container.
  • Use extreme care when inserting a spoon or other utensil into the container.

PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY

• Do not attempt to operate this oven with the door open since open-door operation can result in harmful exposure to microwave energy. It is important not to defeat or tamper with the safety interlocks.
• Do not place any object between the oven front face and the door or allow soil or cleaner residue to accumulate on sealing surfaces.
• Do not operate the oven if it is damaged. It is particularly important that the oven door close properly and that there is no damage to the:
  • Door (bent),
  • Hinges and latches (broken or loosened),
  • Door seals and sealing surfaces.
  • The oven should not be adjusted or repaired by anyone except properly qualified service personnel.

INSTALLATION INSTRUCTIONS

Unpacking

1. Empty the microwave oven of any packing materials.
2. Clean the inside with a soft, damp cloth.
3. Check for damage, such as:
   • A door that is not lined up correctly,
   • Damage around the door, or
   • Dents on the interior or exterior of the microwave oven. If there is any damage, do not operate the microwave oven until a designated service technician has checked
     it and made any needed repairs.

NOTE: To avoid damage to the microwave oven, do not remove microwave inlet cover. See the “Parts and Features” section.

Location Requirements

• Place the microwave oven on a cart, counter, table, or shelf that is strong enough to hold the microwave oven and the food and utensils you place inside it.
• The microwave oven should be at a temperature above
  50°F (10°C) for proper operation.
• Do not block the exhaust vents or air intake openings. Allow a few inches of space at the back and side of the microwave oven where the exhaust vents are located. Blocking the exhaust vents could cause damage to the microwave oven as well as poor cooking results.
• Make sure the microwave oven legs are in place to ensure proper airflow. If vents are blocked, a sensitive thermal device may automatically turn the microwave oven off. The microwave oven should work properly once it has cooled.

Electrical Requirements

WARNING

Electrical Shock Hazard

• Plug into a grounded 3 prong outlet.
• Do not remove ground prong.
• Do not use an adapter.
• Do not use an extension cord.
• Failure to follow these instructions can result in death, fire, or electrical shock.

Observe all governing codes and ordinances.
Required:

• A 120 V, 60 Hz, AC only, 15 or 20 A electrical supply with a
  fuse or circuit breaker.
  Recommended:
• A time-delay fuse or time-delay circuit breaker
• A separate circuit serving only this microwave oven

GROUNDING INSTRUCTIONS

• For all cord-connected appliances:
  The microwave oven must be grounded. In the event of an electrical short circuit, grounding reduces the risk of electric shock by providing an escape wire for the electric current. The microwave oven is equipped with a cord having a grounding wire with a grounding plug. The plug must be plugged into an outlet that is properly installed and grounded.

WARNING: Improper use of the grounding plug can result in a risk of electric shock. Consult a qualified electrician or serviceman if the grounding instructions are not completely understood, or if doubt exists as to whether the microwave oven is properly grounded.
Do not use an extension cord. If the power supply cord is too short, have a qualified electrician or serviceman install an outlet near the microwave oven. A short power supply cord is provided to reduce the risks resulting from becoming entangled in or tripping over a longer cord.

PARTS AND FEATURES

This manual may cover several different models. The model you have purchased may have some or all of the features shown here. The appearance of your particular model may differ slightly from the illustrations in this manual.

A. Window
B. Microwave oven light
C. Display
D. Control panel
E. Microwave inlet cover
F. Removable turntable support
G. Glass turntable
H. Door lock system

Turntable

A. Turntable
B. Hub
C. Support
D. Shaft

The turntable can rotate in either direction to help cook food more evenly. For best cooking results, do not operate the microwave oven without having the turntable in place. See the “Assistance or Service” section to reorder any of the parts.

To Install:

1. Place the support on the microwave oven cavity bottom.
2. Place the turntable on the support.
   Fit the raised, curved wedges in the center of the turntable bottom between the 3 spokes of the hub. The rollers on the support should fit inside the turntable bottom ridge.

MICROWAVE OVEN CONTROL

Display
will appear in the display. If the “12:00” appears in the display at any other time, a power failure has occurred. Reset the clock if needed. See the “Clock” section.

Start
The Start keypad begins any function. If non-sensor cooking
the cycle.
NOTE: To avoid unintentional operation of the microwave oven, a cooking function cannot be started if the microwave oven doorin the display until the door is opened and closed.

Add 30 Seconds
The Start Add 30 Sec keypad automatically starts the microwave oven at 100% power for 30 seconds and adds
control.
Time may be added to any manual cooking cycle in 30 second increments, at the current power level, by touching ADD 30 SEC during cooking.
NOTE: To avoid unintentional operation of the microwave oven, a cooking function cannot be started if the microwave oven door
in the display until the door is opened and closed.

Cancel
The Cancel keypad clears any incorrect command and cancels any program during cooking. Touch the Cancel keypad to cancel the cycle. It will not erase the time of day.
The microwave oven will also turn off when the door is opened. Close the door and touch START to resume the cycle.
The Cancel keypad is also used to lock and unlock the control panel. See the “Control Lock” section.

Clock

This is a 12-hour clock.
To Set:
The microwave oven must be on standby.

1. Touch TIMER for 3 seconds to enter the clock setting. It will also appear every time the product is plugged into the power source or power is back after power failure.
   Touch the +/- button to set the hour.
2. Touch the +/- button to set the hour.
3. Touch the START/+30 sec button to confirm.
4. Touch the +/- button to set the minute.
5. Touch START/+30 sec button to confirm the setting.

Timer

NOTE: The Timer does not start or stop the microwave oven. The function can be set only in Standby mode.
To Set:

1. Touch TIMER.
2. Touch +/- keypads to enter desired time.
3. Touch START.
   When the set time ends, the end-of-timer tone will sound.
4. While the Timer countdown is active in the display, touch CANCEL to cancel the Timer.

MICROWAVE OVEN USE

A magnetron in the microwave oven produces microwaves which reflect off the metal floor, walls, and ceiling and pass through the turntable and appropriate cookware to the food. Microwaves are attracted to and absorbed by fat, sugar, and water molecules
in the food, causing them to move, producing friction and heat which cooks the food.

• To avoid damage to the microwave oven, do not lean on or
  allow children to swing on the microwave oven door.
• To avoid damage to the microwave oven, do not operate
  microwave oven when it is empty.
• Baby bottles and baby food jars should not be heated in
  microwave oven.
• Clothes, flowers, fruit, herbs, wood, gourds, and paper, including brown paper bags and newspaper, should not be dried in the microwave oven.
• Paraffin wax will not melt in the microwave oven because it
  does not absorb microwaves.
• Use oven mitts or pot holders when removing containers
  from microwave oven.
• Do not overcook potatoes. At the end of the recommended cook time, potatoes should be slightly firm. Let potatoes stand for 5 minutes. They will finish cooking while standing.
• Do not cook or reheat whole eggs inside the shell. Steam buildup in whole eggs may cause them to burst, requiring significant cleanup of microwave oven cavity. Cover poached eggs and allow a standing time.

Food Characteristics

When microwave cooking, the amount, size and shape, starting temperature, composition, and density of the food affect cooking results.

• Amount of Food
  The more food heated at once, the longer the cook time needed. Check for doneness and add small increments
  of time if necessary.
• Size and Shape
  Smaller pieces of food will cook more quickly than larger pieces, and uniformly shaped foods cook more evenly than irregularly shaped food.
• Starting Temperature
  Room temperature foods will heat faster than refrigerated foods, and refrigerated foods will heat faster than frozen foods.
• Composition and Density
  Foods high in fat and sugar will reach a higher temperature and will heat faster than other foods. Heavy, dense foods, such as meat and potatoes, require a longer cook time than the same size of a light, porous food, such as cake.

Cooking Guidelines

• Covering
  Covering food helps retain moisture, shorten cook time, and reduce spattering. Use the lid supplied with cookware. If a
  lid is not available, wax paper, paper towels, or plastic wrap approved for microwave ovens may be used. Plastic wrap should be turned back at one corner to provide an opening to vent steam. Condensation on the door and cavity surfaces is normal during heavy cooking.
• Stirring and Turning
  Stirring and turning redistribute heat evenly to avoid overcooking the outer edges of food. Stir from outside to center. If possible, turn food over from bottom to top.
• Arranging
  If heating irregularly shaped or different-sized foods, arrange the thinner parts and smaller-sized items toward the center. If cooking several items of the same size and shape, place them in a ring pattern, leaving the center of the ring empty.
• Piercing
  Before heating, use a fork or small knife to pierce or prick foods that have a skin or membrane, such as potatoes, egg yolks, chicken livers, hot dogs, and sausage. Prick in several places to allow steam to vent.
• Shielding
  Use small, flat pieces of aluminum foil to shield the thin pieces of irregularly shaped foods, bones and foods such as chicken wings, leg tips, and fish tails. See the “Aluminum Foil and Metal” section first.
• Standing Time
  Food will continue to cook by the natural conduction of heat even after the microwave cooking cycle ends. The length of standing time depends on the volume and density of the food.

Cookware and Dinnerware

Cookware and dinnerware must fit on the turntable. Always use oven mitts or pot holders when handling because any dish may become hot from heat transferred from the food. Do not use cookware and dinnerware with gold or silver trim. Use the following chart as a guide, then test before using.

To Test Cookware or Dinnerware for Microwave Use:

1. Place cookware or dinnerware in microwave oven with 1 cup (250 mL) of water beside it.
2. Cook at 100% cooking power for 1 minute.
   Do not use cookware or dinnerware if it becomes hot and the water stays cool.

Aluminum Foil and Metal

Always use oven mitts or pot holders when removing dishes from the microwave oven.
Aluminum foil and some metal can be used in the microwave Oven. If not used properly, arcing (a blue flash of light) can
OcCur and cause damage to the microwave oven.

OK for Use

Racks and bakeware supplied with the microwave oven (on some models), aluminum foil for shielding, and approved meat thermometers may be used with the following guidelines:

• To avoid damage to the microwave oven, do not allow aluminum foil or metal to touch the inside cavity walls,
• Always use the turntable.
• To avoid damage to the microwave oven, do not allow contact with another metal object during microwave cooking.

Do Not Use

Metal cookware and bakeware, gold, silver, pewter, non-approved meat thermometers, skewers, twist ties, foil liners such as sandwich wrappers, staples, and objects with gold or silver trim or a metallic glaze should not be used in the microwave oven.

Microwave Cooking Power
Many recipes for microwave cooking specify which cooking power to use by power level. For example, P70 = Medium-High.
Use the following chart as a general guide for the suggested Cooking power of specific foods.

Manual Cooking

To Use:

1. Touch POWER/TIME to enter power level, default is P100.
2. Touch +/- button to choose power level.
3. Touch POWER/TIME again to adjust the cooking time, default is 15 seconds.
4. Touch +/- button to set the cooking time, then touch START/+30 sec to start cooking.

Cook Menu

The microwave oven has been programmed with common microwavable foods, their quantities, cook powers, and
Use the following chart as a guide for preset cooking.

To Use Cook Menu:

1. Place food on the turntable and close the door.
2. Touch the Cook Menu keypad repeatedly to choose menu.
3. Touch +/- button to change quantity.
4. Touch START/+30 sec.
   The display will count down the cook time. When the cycle ends, “End” will appear in the display and the end-of-cycle tones will sound.

Popcorn

This function allows to cook Popcorn microwaveable bags. Use for 3.5 oz bags only.

To Use:

1. Touch the Popcorn button.
2. Touch START/+30 sec button to start the function.

Soften/Melt

A selection of automatic recipes with preset values to offer optimal cooking results.
To Use:

1. Touch Soften/Melt button repeatedly to select the desired recipe(see the table below).
2. Touch +/- button to select the weight or quantity.
3. Touch the START/+30 sec button. The function will start.

Defrost

• Unwrap foods and remove lids (for example, from fruit juice
  containers) before defrosting.
• Shallow packages will defrost more quickly than
• Separate food pieces as soon as possible during or at the
  end of the cycle for more even defrosting.
• Use small pieces of aluminum foil to shield parts of food Such as chicken wings, leg tips and fishtails. See the
  “Aluminum Foil and Metal section first.

Auto Defrost 

The product provides an automatic defrost for 3 kinds of food.
To Use Auto Defrost:

1. Touch the Defrost menus (see the following chart).
2. Touch the +/- button to set the weight and touch the START/+30 sec button to start.

Manual Defrost

To Use Manual Defrost:

1. Touch Manual Defrost button.
2. Touch +/- button to increase or decrease the time values.
3. Touch START/+30 sec to start.

Steam Clean

This automatic cleaning cycle will help you to clean the microwave oven cavity and to remove unpleasant odors.
Before starting the cycle:

1. Put 250 mL water into a container (see our recommendations in the below section “Tips and suggestions”).
2. Place the container directly on the middle of the cavity.

To Start The Cycle:

1. Press the Steam Clean button, the cleaning cycle duration will be visible on the display.
2. Press the Start button to start the function.

When The Cycle Is Finished:

1. Press the Cancel button.
2. Remove the container.
3. Use a soft cloth or a paper towel with mild detergent to clean the interior surfaces.

Tips and suggestions

For a better cleaning result, it is recommended to use a container with a diameter of 17-20 cm, and a height that is lower than 6.5 cm.
It is recommended to use a container of light plastic material that is suitable for the microwave.
As the container will be hot after the cleaning cycle is completed, it is recommended to use a heat-resistant glove when removing the container from the microwave.
For a better cleaning effect and removal of unpleasant odors, add some lemon juice or vinegar to the water.

Keep Warm
This function allows you to keep your dishes warm automatically.

1. Touch the Keep Warm button.
2. Touch +/- button to select a suitable time, then touch the START/+30 sec button to start. Default time is 30 minutes.

MICROWAVE OVEN CARE

The area where the microwave oven door and frame touch when closed should be kept clean.

• Mild, nonabrasive soaps and detergents:
  Rinse with clean water and dry with soft, lint-free cloth.
• Glass cleaner and paper towels or nonabrasive plastic scrubbing pad:
  Apply glass cleaner to the towel, not directly to the surface.

Stainless Steel (on some models)
To avoid damage to the microwave oven door and exterior, do not use soap-filled scouring pads, abrasive cleaners, steel-wool pads, gritty washcloths, or some paper towels. Rub in direction of the grain.

• Stainless steel cleaner (not included):
  See the “Assistance or Service” section to order.
• All-purpose cleaner:
  Rinse with clean water and dry with soft, lint-free cloth.
• Vinegar for hard water spots

CONTROL PANEL

• Sponge or soft cloth and water:
  Dampen a sponge with water and wipe panel. Dry with a soft cloth.
• n To avoid damage to the control panel, do not use chemical or abrasive cleansers.

TURNTABLE

Replace the turntable immediately after cleaning. Do not operate the microwave oven without the turntable in place.

• Mild cleanser and scouring pad
• Dishwasher

TROUBLESHOOTING

First, try the solutions suggested here. If you need further assistance or more recommendations that may help you
avoid a service call, refer to the warranty or visit http://www.whirlpool.com/product_help. In Canada, visit http://www.whirlpool.ca.
Contact us by mail with any questions or concerns at the address below:

In the U.S.A.:

• Whirlpool Brand Home Appliances Customer eXperience Center 553 Benson Road
  Benton Harbor, MI 49022-2692

In Canada:

• Whirlpool Brand Home Appliances Customer eXperience Centre 200 – 6750 Century Ave. Mississauga, Ontario L5N 0B7

Please include a daytime phone number in your correspondence.

ASSISTANCE OR SERVICE

If you need service:
Please refer to the warranty.

If you need replacement parts:
If you need to order replacement parts, we recommend that you use only factory-specified parts. These factory-specified parts will fit right and work right because they are made with the same precision used to build every new Whirlpool® appliance.
To locate factory-specified parts in your area, call us or your nearest Whirlpool® designated service center.

In the U.S.A.

Call the Whirlpool Customer eXperience Center toll-free:
1-800-253-1301 or visit our website at www.whirlpool.com.
Our consultants provide assistance with:

• Scheduling of service. Whirlpool® appliances designated service technicians are trained to fulfill the product warranty and provide after-warranty service anywhere in the United States.
• Features and specifications on our full line of appliances.
• Referrals to local Whirlpool® appliance dealers.
• Installation information.
• Use and maintenance procedures.
• Accessory and repair parts sales.
• Specialized customer assistance (Spanish speaking, hearing impaired, limited vision, etc.).

For further assistance:
If you need further assistance, you can write to Whirlpool with any questions or concerns at:

Whirlpool Brand Home Appliances Customer eXperience Center 553 Benson Road
Benton Harbor, MI 49022-2692

Please include a daytime phone number in your correspondence.

In Canada

Call the Whirlpool Customer eXperience Center toll-free: 1-800-807-6777 or visit our website at www.whirlpool.ca.
Our consultants provide assistance with:

• Scheduling of service. Whirlpool® appliances designated service technicians are trained to fulfill the product warranty and provide after-warranty service anywhere in Canada.
• Features and specifications on our full line of appliances.
• Referrals to local Whirlpool® appliance dealers.
• Use and maintenance procedures.
• Accessory and repair parts sales.
  For further assistance:
  If you need further assistance, you can write to Whirlpool with any questions or concerns at:
  Customer eXperience Centre Whirlpool Canada
  200 – 6750 Century Ave. Mississauga, Ontario L5N 0B7

Please include a daytime phone number in your correspondence.

Replacement Parts

Glass Turntable
Part Number W11520648
Turntable Support and Rollers Part Number W11520650
Cleaning Supplies
Affresh® Kitchen Appliance Cleaner
Part Number W10355010
Affresh® Stainless Steel Cleaner Part Number W10355016

Turntable Hub
Part Number W11520649
Affresh® Stainless Steel Wipes
Part Number W10355049
Heavy-Duty Degreaser Part Number 31552A