Bosch ALS 25 Garden Leaf Blower Instruction Manual

BOSCH ALS 25 Garden Leaf Blower Safety Notes

Warning! Read these instructions carefully, be famil-iar with the controls and the proper use of the ma-chine. Please keep the instructions safe for later use!

Explanation of symbols on the machine
General hazard safety alert.

Operation

• Never allow children or people unfamiliar with Operation these instructions to use the machine. Local regulations may restrict the age of the operator. When not in use store the machine out of reach of children.
• This tool is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety. Children should be supervised to ensure that they do not play with the appliance.
• Never operate the machine while people, especially children or pets, are nearby.
• The operator or user is responsible for accidents or hazards occurring to other people or their property.
• Other persons and animals should remain at a distance of 3 meters or more when the machine is being used. The operator is responsible for third persons in the working area.
• Use the machine only in daylight or with good artificial light.
• Do not operate the machine when barefoot or wearing open sandals, always wear substantial footwear and long trousers.
• Failure to keep loose clothing from being drawn in- to air intake could result in personal injury.
• Do not operate without tubes in place.
• Failure to keep long hair away from the air inlet could result in personal injury.
• Thoroughly inspect the area where the machine is to be used and remove all wires and other foreign objects.
• Check cable for damage before starting work and replace if necessary. Keep cable away from heat, oil and sharp edges.
• Never operate the leaf blower/garden vacuum with defective guards or shields, or without safety devices, for example, collection bag in place.
• Always ensure all handles and guards supplied are fitted when using the leaf blower/garden vacuum. Never attempt to use an incomplete leaf blower/garden vacuum or one with an unauthorized modification.
• While operating the leaf blower/garden vacuum always be sure of a safe and secure operating position at all times.
• Always be aware of your surroundings and stay alert for possible hazards that you may not hear whilst operate the leaf blower/garden vacuum.
• Do not overreach and keep your balance at all times.
• Always be sure of your footing on slopes.
• Walk, never run.
• Keep all cooling air inlets clear of debris.
• Never blow debris in the direction of bystanders.
• Do not carry the machine by cable.
• The wearing of a face mask is recommended.
• Do not modify this product. Unauthorized modifications may impair the safety of your product and may result in increased noise and vibration.

Remove the plug from the socket

• before checking, clearing a blockage or working on the leaf blower/garden vacuum.
• after striking a foreign object, inspect the leaf blower/garden vacuum for damage and make repairs as necessary.
• if the leaf blower/garden vacuum starts to vibrate abnormally check immediately.

Power supply

• The voltage indicated on the rating plate must correspond to the voltage of the power source.
• We recommend that this equipment is only connected to a socket that is protected by a circuit-breaker that would be actuated by a 30 mA residual current.
• Only use or replace power supply cables for this unit that correspond to the types indicated by the manufacturer. See the operating instructions for order no. and types.
• Never touch the mains plug with wet hands.
• Do not run over, crush or pull the power supply cable or extension lead, otherwise, it may be damaged. Protect the cable from heat, oil, and sharp edges.
• The extension lead must have a cross-section in accordance with the operating instructions and be protected against splashed water. The connection must not be in the water.

Electrical Safety

• Motor Protector fitted! Motor fitted with safety overload protection. If the motor stops working, allow a few minutes to cool, before restarting.
• Warning! Switch off, remove plug from mains before adjusting, cleaning or if the cable is cut, damaged or entangled.

Your machine is double insulated for safety and requires no earth connection. The operating voltage is 230 V AC, 50 Hz (for non-EU countries 220 V, 240 V as applicable). Only use approved extension cables. Con-tact your Bosch Service Centre for details.
Extension cords/leads should only be used if they comply with H05VV-F, H05RN-F types or IEC type design (60227 IEC 53, 60245 IEC 57).
If you want to use an extension cable when operating your product, only the following cable dimensions should be used:

• 1.0mm2: max. length 40 m
• 1.5 mm2: max. length 60 m
• 2.5 mm2: max. length 100 m

Note: If an extension cable is used it must be earthed and connected through the plug to the earth cable of your supply network in accordance with prescribed safety regulations.
If in doubt contact a qualified electrician or the nearest Bosch Service Centre.
WARNING! Inadequate extension cables can be dangerous. Extension cable, plug and socket must be of watertight construction and intended for outdoor use.
It is recommended for increased electrical safety to use a Residual Current Device (RCD) with a tripping current of not more than 30 mA. Always check your RCD every time you use it.
For products not sold in GB:
WARNING: For your safety, it is required that the plug attached to the machine is connected with the extension cord. The coupling of the extension cord must be protected against splash water, be made of rubber or coated with rubber. The extension cord must be used with a cable strain relief.
The connection lead must be inspected for signs of damage at regular intervals and may only be used if in perfect condition.
If the supply cord is damaged, it must be replaced by a Bosch Service Centre.
Products sold in GB only: Your product is fitted with a BS 1363/A approved electric plug with an internal fuse (ASTA approved to BS 1362).
If the plug is not suitable for your socket outlets, it should be cut off and an appropriate plug fitted in its place by an authorized customer service agent. The replacement plug should have the same fuse rating as the original plug.
The severed plug must be disposed of to avoid a pos-sible shock hazard and should never be inserted into a mains socket elsewhere.
Products sold in AUS and NZ only: Use a residual cur-rent device (RCD) with a rated residual current of 30 mA or less.

Maintenance

• Keep all nuts, bolts and screws tight to ensure that the leaf blower/garden vacuum is always in a safe working condition.
• The leaf blower/garden vacuum should be stored in a dry, high or locked up place out of the reach of children.
• Replace worn or damaged parts for safety.
• Check the collection bag frequently for wear or deterioration.
• Do not attempt to repair the machine unless you are qualified to do so.
• Ensure replacement parts fitted are Bosch approved.

Symbols

The following symbols are important for reading and understanding the operating instructions. Please take note of the symbols and their meaning. The correct interpretation of the symbols will help you to use the garden product in a better and safer manner.

Intended Use
The product is indented for blowing and collecting leaves, garden waste such as grass and twigs in the ar-ea around the garden and house.

Technical Data

The values given are valid for a nominal voltage [U] of 230 V. For different voltages and models for specific countries, these values can vary.
Please observe the article number on the type plate of your garden product. The trade names of the indi-vidual garden products may vary.
Starting cycles generate brief voltage drops. Interfer-ence with other equipment/machines may occur in case of unfavourable mains system conditions. Mal-functions are not to be expected for system imped-ances below 0.36 ohm.

Noise/Vibration Information

Measured sound values determined according to EN 60335.
Typically the A-weighted noise levels of the product are Sound pressure level 82 dB(A); sound power level 102 dB(A). Uncertainty K =3 dB.
Wear hearing protection!
Vibration total values ah (triax vector sum) and uncer-tainty K determined according to EN 60335: ah<2.5 m/s2, K =1.5 m/s2.

Declaration of Conformity

We declare under our sole responsibility that the prod-uct described under “Technical data” is in conformity with the following standards or standardization docu-ments: EN 60335 according to the provisions of the di-rectives 2004/108/EC, 2006/42/EC, 2000/14/EC. 2000/14/EC: Guaranteed sound power level 105 dB(A). Conformity assessment procedure accord-ing to Annex V.
Equipment category: 34, 35
Technical file at: Bosch Lawn and Garden Ltd., PT-LG/EAE, Stowmarket, Suffolk IP14 1EY, England
Noise/Vibration Information
Measured sound values determined according to EN 60335.
Typically the A-weighted noise levels of the product are: Sound pressure level 82 dB(A); sound power level 102 dB(A). Uncertainty K =3 dB.
Wear hearing protection!
Vibration total values ah (triax vector sum) and uncertainty K determined according to EN 60335: ah<2.5 m/s2, K =1.5 m/s2.
Declaration of Conformity
We declare under our sole responsibility that the product described under “Technical data” is in conformity with the following standards or standardization documents: EN 60335 according to the provisions of the directives 2004/108/EC, 2006/42/EC, 2000/14/EC. 2000/14/EC: Guaranteed sound power level
105 dB(A). Conformity assessment procedure according to Annex V.
Equipment category: 34, 35
Technical file at:
Bosch Lawn and Garden Ltd., PT-LG/EAE, Stowmarket, Suffolk IP14 1EY, England

Dr. Eckhard Strötgen Head of Product Certification
Robert Bosch GmbH, Power Tools Division D-70745 Leinfelden-Echterdingen 01.04.2011

Mounting and Operation

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Working Advice

When operating, always hold the machine close to the ground. Do not blow hot, flammable or explosive material. The garden vacuum is only suitable for foliage and gar-den waste. Please inspect the area for little animals and hard objects before using the tool.
Do not vacuum liquids, plastic bags, cans, pine cones, branches larger than 5 mm, cloth, tissues and pegs.

Troubleshooting

Maintenance and Service

Maintenance, Cleaning and Storage

• Before any work on the machine itself, pull the mains plug.

For safe and proper working, always keep the garden product clean. For safe and proper working, always keep the garden product and the ventilation slots clean. Remove dirt on the machine or the collection bag with a moist cloth. Never spray with or immerse the garden product in water. Store the garden product in a secure, dry place, out of the reach of children. Do not place other objects on the garden product.

After-sales Service and Customer Assistance
www.bosch-garden.com
In all correspondence and spare parts orders, please always include the 10-digit article number given on the type plate of the garden product.
Great Britain
Robert Bosch Ltd. (B.S.C.)
P.O. Box 98 Broadwater Park North Orbital Road
Denham Uxbridge UB 9 5HJ
Tel. Service: +44 (0844) 736 0109
Fax: +44 (0844) 736 0146
E-Mail:
www.bosch-garden.com
Origo Ltd.
Unit 23 Magna Drive Magna Business Park
City West
Dublin 24
Tel. Service: +353 (01) 4 66 67 00
Fax: +353 (01) 4 66 68 88
Australia, New Zealand and Pacific Islands
Robert Bosch Australia Pty. Ltd.
Power Tools Locked Bag 66 Clayton South VIC 3169 Customer Contact Center
Inside Australia:
Phone: +61 (01300) 307 044
Fax: +61 (01300) 307 045
Inside New Zealand:
Phone: +64 (0800) 543 353
Fax: +64 (0800) 428 570
Outside AU and NZ:
Phone: +61 (03) 9541 5555
www.bosch.com.au
Republic of South Africa
Customer service
Hotline: +27 (011) 6 51 96 00
Gauteng – BSC Service Centre 35 Roper Street, New Centre Johannesburg
Tel.: +27 (011) 4 93 93 75
Fax: +27 (011) 4 93 01 26
E-Mail: b
KZN – BSC Service Centre Unit E, Almar Centre 143 Crompton Street
Pinetown
Tel.: +27 (031) 7 01 21 20
Fax: +27 (031) 7 01 24 46
E-Mail:
Western Cape – BSC Service Centre Democracy Way, Prosperity Park Milnerton
Tel.: +27 (021) 5 51 25 77
Fax: +27 (021) 5 51 32 23
E-Mail: b
Bosch Headquarters Midrand, Gauteng
Tel.: +27 (011) 6 51 96 00
Fax: +27 (011) 6 51 98 80
E-Mail: [email protected]

Disposal

The garden product, accessories and packaging should be sorted for environmental-friendly recycling.
Do not dispose of garden products into household waste!
Only for EC countries:
According to the European directive 2002/96/EC for Waste Electrical and Electronic Equipment and its imple-mentation into national law, electrical and electronic equipment that are no longer usable must be collected sepa-rately and disposed of in an environ-mentally correct manner.