Bosch PPC6A….. Gas Hob Instruction Manual

Register your new device on MyBosch now and get free
benefits: bosch-home.com/welcome

Gas hob PPC6……PPC6A…….PPH6A……PPQ7A…….PPS7A…….PPS9A…….
Instruction manual

1. Pan supports
2. Control knobs
3. Economy burner with an output of up to 1 kW
4. Standard-output burner with an output of up to 1.75 kW

Intended use

Read these instructions carefully. You will only be able to use your appliance safely and effectively when you have read them. These operating and installation instructions should be retained and passed onto the buyer if the appliance is sold.
The manufacturer Is exempt from all responsibility if the requirements of this manual are not complied with.
The images shown in these instructions are for guidance only.
Do not remove the appliance from its protective packaging until it is installed in the unit. Do not switch on the appliance if it is damaged in any way. Contact our Technical Assistance Service.
This appliance is class 3 type, according to the EN 30-1-1 regulation for gas appliances: built-in appliance.
Before installing your new hob, ensure that it is being installed according to the installation instructions. This appliance cannot be installed on yachts or in caravans. This appliance must only be used in well-ventilated places. This appliance is not intended for operation with an external clock timer or remote control.
All operations relating to installation, connection, regulation, and conversion to other gas types must be performed by an authorized technician, respecting all applicable regulations, standards, and specifications of the local gas and electricity suppliers. Special attention shall be paid to ventilation regulations.
This appliance leaves the factory set to the gas type that is indicated on the specifications plate. If this needs to be changed, please consult the assembly instructions. It is recommended you contact the Technical Assistance Service to change to another gas type.
This appliance has been designed for home use only, not for commercial or professional use. This appliance is only intended for cooking purposes, not as a heating system. The warranty will only be valid if the appliance is used for the purpose for which it was designed.  This appliance is intended for use up to a maximum height of 2000 meters above sea level.
Do not use lids or hob guards for children which are not recommended by the hob manufacturer. They may cause accidents such as those due to the overheating, ignition, or detachment of fragments of materials.
This appliance may be used by children over the age of 8 years old and by persons with reduced physical, sensory or mental capabilities or by persons with a lack of experience or knowledge if they are supervised or are instructed by a person responsible for their safety how to use the appliance safely and have understood the associated hazards. Children must not play with, on, or around the appliance. Children must not clean the appliance or carry out general maintenance unless they are at least 15 years old and are being supervised.
Keep children below the age of 8 years old at a safe distance from the appliance and power cable.

Important safety information

Warning — Risk of deflagration! Accumulation of unburned gas in an enclosed area carries a risk of deflagration. Do not subject the appliance to draughts. These might blow out the burners. Carefully read the instructions and warnings on the operation of gas burners. &Warning — Risk of poisoning! The kitchen will become hot and humid and combustion products produced when this gas appliance is used. Make sure the kitchen is well ventilated, particularly when the hob is in operation: either keep the natural ventilation apertures open or install a ventilation system (extractor hood). Intense prolonged use of the appliance may require additional or more effective ventilation: open a window or increase the power of the ventilation system.
Warning — Risk of burns!

• The burners and their immediate vicinity get very hot. Never touch the hot surfaces. Keep children under 8 years old well away from this appliance.
• If the liquefied gas bottle is not upright, liquefied propane/butane can enter the appliance. Intense darting flames may therefore escape from the burners. Components may become damaged and start to leak over time so that gas escapes uncontrollably. Both can cause burns. Always use liquefied gas bottles in an upright position.

Warning — Risk of fire!

• The cooking process must be supervised. A short cooking process must be supervised without interruption.
• The burners get very hot. Do not rest inflammable objects on the hob.
• Do not store objects on the hob. . Do not store or use corrosive chemicals, products that produce fumes, inflammable materials or non-food products below or near this domestic appliance. .
• Fat or oil which is overheated can catch fire easily. Never leave fat or oil to heat up unattended. If oil or fats do catch fire, never use water to put the fire out. Put the fire out by covering the pan with a lid and switching off the hotplate.

Warning — Risk of Injury!

• Cracks or fractures in the glass plate are dangerous. Shut immediately off all burners and any electrical heating element. Unplug the appliance from the mains or switch off the circuit breaker in the fuse box. Shut off the gas supply. Do not touch the appliance surface. Never switch on a faulty appliance. Contact the after-sales service.
• Sudden changes in temperature may cause breakage of the glass. While using your hob, prevent any draughts and do not spill any cold liquids on it.
• Pans that are damaged, are not the right size, hang over the edge of the hob, or are not positioned correctly can cause serious injuries. Follow the advice and warnings. In provided relating to the cooking pans. correct repairs are dangerous. Repairs may only be carried out, and damaged power and gas lines replaced, by an after-sales engineer trained by us. If the appliance is faulty, unplug the mains plug or switch off the fuse in the fuse box. Shut off the gas supply. Contact the after-sales service.
• If a control knob is too stiff to turn or it is loose, it must not be used. Contact our after-sales service immediately to have the control knob repaired or replaced.

Warning — Risk of electric shock!
Do not clean the appliance using steam cleaners. Cracks or fractures in the glass plate could cause electric shocks. Switch off the circuit breaker in the fuse box. Contact the after-sales service.

Getting to know your appliance

You can find your appliance and the burner powers in the model overview. —) Page 2
Controls and burners
Each control knob is marked with the burner it controls. You can use the control knobs to set the output required in each case to various positions between the maximum and the minimum settings. Never try to switch directly from position 0 to position 1 or from position 1 to position 0.

Indicators
Burner controlled by control knob
o Switched-off burner 9 la
Highest power setting and electric ignition
Lowest power setting
It is essential to ensure that all the burner parts and pan supports are correctly installed for the appliance to work correctly. Do not swap the burner caps around. Always remove the pan supports carefully. When moving pan support. the pan supports next to it may also move.

Burner parts
I Ignition plug
2 Thermocouple
3 Burner cup
4 Burner cap

Accessories
Depending on the model. the hob may include the following accessories. These can also be acquired from the Technical Assistance Service.

Code  
HEZ298126 Additional wok grid: Cast iron (mini wok burner) HEZ298127 Additional wok grid: Cast iron (4.5 kW) HEZ298110 Additional wok grid: Enamelled steel HEZ298114 Additional espresso maker grid HEZ211310 Simmer cap
The manufacturer accepts no liability if these accessories are not used or are used incorrectly.

Gas burners

Switching on manually

1. Press the control knob for the selected burner and turn it anticlockwise to the highest power setting.
2. Hold an igniter or a naked flame (such as a lighter or a match) against the burner.

Automatic ignition

If the hob has automatic ignition (ignition plugs):

1.  Press the control knob for the selected burner and turn it anticlockwise to the highest power level. While the control knob is held down, all the burners will generate sparks. The flame ignites. Wait a few seconds.
2. Release the control knob.
3. Turn the control knob to the required position. If the burner does not ignite, switch it off and repeat the steps described above. This time. hold the control knob down for longer (up to 10 seconds).

Warning — Risk of deflagration! If the flame does not ignite after 15 seconds. switch off the burner and open a window or the door to the room. Wait at least one minute before switching the burner on again.
Note: It is important to keep the appliance clean. If the ignition plugs are dirty. this may cause ignition problems. Clean the ignition plugs regularly with a small, non-metallic brush. Take care to prevent the ignition plugs from suffering any heavy knocks.
Safety system
Your hob is equipped with a safety system (thermocouple) that cuts off the gas when the burners are accidentally switched off.
To ensure that this device is active:

1. Switch on the burner as usual.
2. Without releasing the control knob, press and hold it down firmly for 4 seconds after lighting the flame.

Switching off a burner
Turn the corresponding control knob clockwise to the 0 settings.
A few seconds after the burner is switched off, a sound (thud) will be produced. This is not a fault – this means that the safety device is no longer operating.
main switch/Hob lock (Main Switch)
The hob may have the main switch to cut off the mains gas supply and switch off all the burners at the same time. This switch is very practical if there are children in the house. if for any reason, all the burners must be switched off quickly.
To lock the hob:
Press the main switch. This switches off all the burners which are on. The hob is locked.

To unlock the hob:

1. Turn all the control knobs to the ‘oh’ position.
2. Press the main switch and turn it fully clockwise.
   
   The mains gas supply is turned on. You can now use your hob normally.

Warnings
It is normal to hear a soft whistling noise while the burner is operating. When first used, it is normal for the burner to give off odors. This does not pose any risk and does not indicate a malfunction. They will disappear in time. An orange-colored flame is normal. This is caused by the presence of dust in the atmosphere, spilling liquids. etc. In the event of the burner flames being accidentally extinguished, turn off the burner control and do not attempt to re-ignite the burner for at least one minute.

Settings table and tips

Suitable pans

The cookware must not overhang the edge of the hob. You should only use cookware with a domed base if your cooktop features a wok burner and the additional wok grid. The additional wok grid must be correctly positioned.
Precautions for use
The following advice is intended to help you save energy and prevent pan damage:

Table of cooking times
The table below lists the optimal heat settings and cooking times for various types of food. The information given applies when cooking four portions. The cooking times and heat settings may vary depending on the type of food, its weight and quality, the type of gas used, and the material from which the cookware is made. To prepare this dish, stainless steel cookware was mainly used. Always use cookware that is the right size and place it in the center of the burner. You can find information about the diameter of the cookware under —> “Suitable pans”
Information on the table Each type of food can be prepared in one or two steps. Each step includes the following information:
Cooking position
Cooking time in minutes
At the table, you will find information on how to cook food on different burners. We recommend using the first burner. The model overview describes all the burners on the hob.—* Page 2

Cooking tips

• Use a pressure cooker to cook creamy soups and pulses. This significantly reduces the cooking time. If you are using a pressure cooker, follow the manufacturer’s instructions. Add all of the ingredients at the start.
• Always use a lid when cooking potatoes and rice. This significantly reduces the cooking time. The water must be boiling before you add pasta, rice or potatoes. Then adjust the heat setting to continue boiling.
• For pan-cooked dishes, heat the oil up first. As soon as you have started the frying, keep the pan at a constant temperature by adjusting the heating setting as required. When preparing several portions, wait until the relevant temperature has been reached again. Turn the food regularly.
• When cooking soups, cream, lentils, or chickpeas, add all of the ingredients to the cookware at the same time.

cleaning and maintenance

Cleaning
Once the appliance is cool, use a sponge to clean it with soap and water. After each use, clean the surface of the respective burner parts once they have cooled down. II any residue is left (baked-on food, drops of grease, etc.). however little. it will become stuck to the surface and more difficult to remove later. The holes and grooves must be clean for the flame to ignite properly. The movement of some parts may leave metal residue on the pan supports. Clean the burners and pan supports using soapy water and scrub with a non-wire brush. If the pan supports are fitted with rubber rests, ensure that these are also cleaned. The rests may come loose and the pan support may scratch the hob. Always dry the burners and pan supports completely. Water droplets or damp patches on the hob at the start of cooking may damage the enamel. After cleaning and drying the burners, make sure the burner caps are correctly positioned on the diffuser.
Caution!

• Do not remove the control knobs when cleaning the appliance. The appliance may be damaged if moisture finds its way inside.
• Do not use steam cleaners. This could damage the hob.
• Never use abrasive products. steel scourers. sharp implements. knives. etc. to remove bits of hardened food from the hob.
• Do not use knives. scrapers or similar implements to clean the point where the glass meets the bumper trims. the metal frames or the glass/aluminum panels, if fitted.
• Do not put the burner components in the dishwasher.

Maintenance
Always clean off any liquid as soon as it is spilled. This will prevent food remains from sticking to the hob surface and you will save yourself any unnecessary effort. Never slide pans across the glass surface. as you may scratch it. In addition, try not to drop heavy or sharp objects on the glass. Never strike any part of the hob. Grains of sand that may come from cleaning fruits and vegetables will scratch the glass surface. Melted sugar. or foods that contain a lot of sugar that may have spilled. should be cleaned off the hob immediately, using the glass scraper.

Troubleshooting

Sometimes certain faults detected can be easily resolved. Before calling the Technical Assistance Service, bear in mind the following advice:

Customer service

When contacting our customer service, please provide the product number (E-Nr.) and production number (FD) of the appliance. This information is given on the specifications plate located on the lower section of the hob and on the label in the user manual. Please find the contact data of all countries in the enclosed customer service list.
To book an engineer visit and product advice
GB 0344 892 8979 Calls charged at local or mobile rate.
IE 01450 2655 0.03 € per minute at peak. Off-peak 0.0088 € per minute.
Rely on the professionalism of the manufacturer. You can therefore be sure that the repair is carried out by trained service technicians who carry original spare parts for your appliances.
Warranty conditions
In the unlikely event that the appliance is damaged or does not meet your expectations in terms of quality, please inform us as soon as possible. For the warranty to be valid, the appliance must not have been tampered with or used inappropriately. The applicable warranty conditions are those set out by the company’s representative office in the country of purchase. Detailed information is available from retail outlets. Proof of purchase must be presented to obtain the benefits of the warranty. We reserve the right to introduce changes.

Environmental protection

If the symbol is shown on the specifications plate, bear in mind the following instructions:
Environmentally-friendly disposal
Dispose of packaging in an environmentally-friendly manner.
This appliance is labeled in accordance with European Directive 2012/19/EU concerning used electrical and electronic appliances (waste electrical and electronic equipment – WEEE). The guideline determines the framework for the return and recycling of used appliances as applicable throughout the EU.
The packaging of your appliance has been manufactured using only the materials which are strictly necessary to guarantee efficient protection during transport. These materials are 100% recyclable, thus reducing the environmental impact. You can also contribute to caring for the environment by following the advice below:

• Dispose of the packaging in the appropriate recycling bin.
• Before you get rid of an old appliance, make sure you disable it. Contact your local authority to find out the address of your nearest recycling center to dispose of your appliance.
• Do not pour used oil down the sink. Collect it in a sealed container and take it to an appropriate collection point or, failing that, place it in the rubbish bin (it will end up in a controlled dump; this is probably not the best option, but it will avoid contaminating groundwater).

Thank you for buying a Bosch Home Appliance!

Register your new device on MyBosch now and profit directly from:

• Expert tips & tricks for your appliance
• Warranty extension options
• Discounts for accessories & spare parts
• Digital manual and all appliance data at hand
• Easy access to Bosch Home Appliances Service
  Free and easy registration – also on mobile phones: www.bosch-home.com/welcome

Looking for help? You’ll find it here.

Expert advice for your Bosch home appliances needs help with problems or a repair from Bosch experts. Find out everything about the many ways Bosch can support you: www.bosch-home.com/service Contact data of all countries are listed in the attached service directory.

Robert Bosch Hausgerate GmbH
Carl-Wery-Stra8e 34 81739 Munchen Germanywww.bosch-home.com
Valid within Great Britain:
Imported to Great Britain by BSH Home Appliances Ltd
Grand Union House Old Wolverton Road
Wolverton, Milton Keynes MK125PT United Kingdom  9001285868
010917